RangeRovers.net Forum banner

zf5hp24

  1. problem with reverse in ZF5HP24

    Range Rover Mark III / L322
    Hi all My L322 has the ZF5HP24 is experiencing problems when engaging reverse, there is prolonged period of wait time before the reverse gear engages. Sometimes the selecting of reverse is smooth and other times is quite rough making the vehicle jolt. Hoping Phil will see this and be able to...
  2. ZF5HP24, Gear Check 2

    Range Rover Mark III / L322
    So, there is an issue with a trans. Trans works fine when driving smoothly in D mode. But in S mode, during aggressive accelerating trans goes to Fail Safe Mode. There are two errors stored in EGS: 49 Symptom gear check 52 Gear Check 2 These two errors always appearing (after clearing) and...
  3. Transmission issue ZF5HP24

    Range Rover Mark III / L322
    Hello everybody out there, I have an issue with my Mark III, 96K. It seems to have been a textbook example of a faulty torque converter with occasional vibration between 30 and 55mph, as well as some shuddering. It did change at 56mph when the LUC engages, as RRPhil described, so planning to...
  4. ZF5HP24 swap question

    Range Rover Mark III / L322
    my ZF5HP24 on my 2003 rover is slipping. I have found a ZF5HP24 from a 2005 rover (both have the 4.4 BMW engine). Is this a direct swap? Will the 05 trans need any kind of "programing" to work with my car? thanks in advance.
  5. How to fit 8 litres of oil into a ZF5HP24 finally revealed!

    Range Rover Mark III / L322
    Regular readers may remember I've had issues with my ZF 5HP24 overheating and locking into 3rg gear since a LR 'Specialist' service centre performed a gearbox oil change. I checked the level 600km after the service to discover it had been overfilled by approximately three litres! (they billed me...
  6. Rebuilt ZF5HP24 bucking when downshifting, engages hard.

    Range Rover Mark III / L322
    Hello all thanks for reading, Builder replaced the failed B-Drum, valve body, hard parts and the torque converter on a ZF5HP24. So now the car engages into drive and reverse hard and vehicle lurches/lunges when doing so. When coasting to a stop the car bucks as it is downshifts thru the gears...
  7. 2002 L322 4.4 zf5hp24 transmission problems

    Range Rover Mark III / L322
    Hi folks, I'm new to the forum, looking for a bit advice with my auto box, which has a couple of faults. First one is when you select drive or reverse, within a second or two it engages with a bit of a thud/snatch, this happens every time hot or cold, worse when it's hot. The second fault is...
  8. L322 ZF5HP24 Torque Converter knock?? Advice needed!

    Range Rover Mark III / L322
    Hi Guys, I am new to the forum, so first of all I'd like to thank everyone who has contributed so much to make this forum such a valuable resource. I've had a 03 4.4L L322 (ZF5HP24) since the start of the year, and have been gradually working through some needed maintenance. I have suspected...
  9. P38 with BMW M57 and ZF5HP24

    Range Rover Mark II / P38
    Hi, Happens to be so that I have a -00 730d and -99 4.6 P38. I started to think that what if I take the motor and transmission from e38 to P38. Some adapter fabrication is needed between auto- and transferbox plus some "minor" electrics work. `) Has this been already done? I am not worried...
  10. ZF5HP24 Hunting and vibration into overdrive. Whats wrong?!

    Range Rover Mark III / L322
    Hi All, So, I'm hoping to get a little more exposure by giving my problem a more appropriate title. Originally i thought the issue was with the engine, however it seems to be pretty much completely transmission related. These are my symptoms. 1) Below about 92km/h, the car will not stay...
  11. ZF5HP24 Gearbox Water Contaminated

    Range Rover Mark III / L322
    I have encountered a strange issue. Some time back I posted a problem whereby my car had a shudder immediately after installing a newly overhauled torque converter. Prior to the overhaul there was zero shudder and I had it done due to an excessive whining noise coming from the torque converter...
  12. 2004 range rover hse transmission problem after rebuild

    Range Rover Mark III / L322
    I have a 2004 range rover hse that i just had transmission rebuilt in.It shows a trans failsafe code after you drive it about 15 mins which in turn makes the hdc inactive,air suspension inactive,abs and brake light come on but if you shift it manually you can drive it all day long with no codes...
  13. Transmission problem ZF 5hp24 - jolt when going down into 2nd only

    Range Rover Mark III / L322
    Transmission problem ZF 5hp24 - jolt when going down into 2nd only Hi guys, once again... more gearbox problems. So Ive just had a reconditioned box put in. Drove fine for 2 days but now it has a jolt when changing down from 3rd into 2nd. Doesnt do it in any other gears. Also it never did this...
  14. My ZF-5hp24 gearbox issue, thoughts?

    Range Rover Mark III / L322
    Hello Everyone, I am new to the forum but have been poking around and doing looks of reading for a while, If you could take a minute to read my symptoms and tell me your initial thoughts that would be most appreciated. I have a 2002 ZF-5hp24, only had the vehicle for a month and don't know...
  15. yet another ZF5HP24 transmission problem!

    Range Rover Mark III / L322
    i just picked up an 03 Range Rover l322 4.4 V8 with the ZF5HP24 transmission. has 110k on the clock. when i first got the truck, the transmission had signs of having worn torque converter lockup clutches. at different times it sounded like i was veering off the road and hitting the rumble...
  16. Great ZF5HP-24 Transmission Repair Shop in North Georgia

    Range Rover Mark III / L322
    I recently bought my brother's 2004 Range Rover after the trans failed and he did not want to spend any more money on it. I have had a great experience with Transmissions by Shane in Martin, GA (about 85 miles NE of Atlanta, GA just off I-85) Shane rebuilt the transmission for just under...
  17. zf5hp24

    Range Rover Mark III / L322
    what is the right gear or way to see if gearbox oil level is right on zf5hp24/4.4vogue
  18. zf5hp24 gearbox

    Range Rover Mark III / L322
    Lads im new on here so thanks for any info done an oil change 2k ago on gearbox new filter and oil so wife was driveing it the other night and it give a wine out of it and just felt as if it was slipping so i went out and got it back to workshop drive ok and 5 min down the road started slipping...
  19. Rebuilding ZF5HP24

    Range Rover Mark III / L322
    A few weeks back my 2003 l322 trans went into limp mode. I've been having problems with the Trans for a while, firstly with overheating which seemed to sort itself after I replaced the radiator, and then with surging at 80Kph (about 100rpm up and down) which I figured was the Torque Converter...
  20. 2004 M62 ZF5HP24 95K miles Maintenance Questions.....

    Range Rover Mark III / L322
    Hello All: Turning 95K miles with no problems, but only had it since 89K, so thought I would tackle a few things now that I am back home and can work on it... Most of the 6K miles since purchase have been highway... and last 1,000 miles was towing 5,000lbs... Surprisingly Stable Towing...
Top