RangeRovers.net Forum banner

flap

  1. Cracked Heater Box Distribution Flap Lever

    Range Rover Mark II / P38
    I set about replacing the blend motors on my '97 P38, while also taking the opportunity to replace a warped dash. Everything was going great until I arrived at the left side distribution flap lever and found the mechanism cracked where the blend motor engages the gear to move the flap. Attempts...
  2. Fuel flap actuator rendomly releases door.

    Range Rover Classic
    Hi all, Here is another of those issues that left me scra tching my head. The fuel flap actuator randomly releases the door, which randomly opens while I drive, when I start the car, or even when the car is stopped. I replaced the part, but the problem persists. Fortunately, the fuel flap...
  3. HVAC recircuation flap door for air conditioning sound

    Range Rover Mark III / L322
    Hey guys, So new to LR community...my 2011 RR Supercharged I picked up a few months ago has this squealing/hissing sound coming from inside the cabin. I took it in and the mechanic thought it was the HVAC recirculation doors not sealing anymore or sealing improperly. The car is still under...
  4. Tailgate flap springs

    Range Rover Mark II / P38
    Can anyone help me to solve how the springs of the tailgate flap (the plastic cover over the gap between tailgate and boot floor) have to be mounted? The springs are there, but I can't figure out how they are set to press the flap down, when tailgate is opened. So the flap just stays upright...
  5. Recirculation flap - cog alignment

    Range Rover Mark II / P38
    Hi All, A quick one - when refitting a recirc motor Rave says to have the air flap open, but do you also have to align the quadrant? If so, is the alignment critical?
  6. Good blend motor & flap, still no drivers heat.

    Range Rover Mark II / P38
    So I have the typical no heat drivers side issue and when adjusting the temp level up and down I hear no movement from the blend motor. Pass side temp works fine as does distro blend motor for air above and below. Only other issue is clicking from pass side recirculation blend motor which I...
  7. How do I change D/S freshair /recirc flap motor ?

    Range Rover Mark II / P38
    My Drivers side fresh air vent is stuck on recirculate and I need it to work, I have dismantled a bit of he dash and I have the D/S fan motor out but I cant get to the intake flap valve motor assembly. How do I get to it ? Do I need to remove the dash top ? or do I have to remove the whole dash...
  8. Throttle flap gap???

    Range Rover Mark II / P38
    Hi all. I'm trying to find some info for the throttle position gap in the throttle housing for my 96 4.0 SE. Reason is I have not long bought the car and have had to replace the LPG vaporizer and now LPG working fine. But i noticed that the previous owner had bent the throttle stop part of the...
  9. No Heat on Left Side - Temp Blend Motor and Flap Work

    Range Rover Sport / L320
    I need help figuring out why my left side heat is not working. Here is the situation: - No heat on left side in all zones, defrost/face-feet/ - Cooling left side operational - Right side heat and cool operational - Left and right temp blend motors and flaps operational. Verified with endoscope...
  10. Fuel filler flap issues

    Range Rover Mark II / P38
    I recently bought a P38 and to my surprise found that the fuel flap button was jammed down. Had a quick search and found how to open it manually from inside the boot. I took the flap off until I sourced a new button. Changed the button then when I went to put the cap back on it wouldn't clip...
  11. Fuel Filler Flap

    Range Rover Mark II / P38
    Hi, I bought a used actuator with the string for my RR which didn't have the string for the fuel door originaly. My problem is the string has seperated/ not connected & I can't find the place where it should attached to in the solenoid arm. Can someone show me a photo, pls? thanks & rgds
  12. In a flap

    Range Rover Mark II / P38
    Hi to All, Just noticed that my front off side mud flap (RHD) was all but off just one screw holding it on, went on to ebay to source a new one prices range from £53.20 inc post to £140.25 inc post don’t know about you but I can find much better things to spend fifty odd quid on, so I set about...
  13. Recirculation flap stuck open - reach for the tin foil ....

    Range Rover Mark II / P38
    Hi All, What with the hot weather starting to bite, I must replace the RH recirculation flap motor. (the LH is fine). When both flaps are closed, the a/c is noticeably cooler. Now, I have the spare recirc. motor, another fan to fit whilst I'm there, but last night I had a brainwave (wait for...
  14. Got tired of pulling a string on gas flap

    Range Rover Mark II / P38
    Hello Rovers, :oops:I am afraid I burnt something that is stopping obdII from communicating with state dmv.
  15. Blend flap motore

    Range Rover Mark II / P38
    Hi to All, You may have seen recently my post with regards to the heating flap motor on the drivers side of my R/H vehicle, I have now replaced this motor and decided to strip out the old unit to see what makes it tic, I had read on several post that on no account should you run this unit while...
  16. Blend Flap motors

    Range Rover Mark II / P38
    Hi to all, I'm considering changing the blend flap motor on the right hand side on my vehicle ( RHD) but have been informed that i will need to have it re-calibrated my question is has any one carried out this operation without the need to re-calibrate. Best regards sillyboy
  17. HEVAC Book Symbol (Revisited for the Nth time) and Flap motor swap HOWTO

    Range Rover Mark II / P38
    HEVAC Book Symbol (Revisited for the Nth time) and Flap motor swap HOWTO So I've had the dreaded book symbol for a while along with ambient air only on the passenger side (LH Drive vehicle) and low airflow generally.The wife stated in not so many terms that even just a short trail ride was out...
  18. disassemble blend flap wiring connector?

    Range Rover Mark II / P38
    How do you pull the pins out of the blend flap motor connector?
  19. Fuel Filler Flap Manual Release???

    Range Rover Mark II / P38
    Aloha everyone! I am in dire need of opening my fuel filler flap. Is there anyway to manually release/open the fuel filler flap for a 1996 Range Rover? My switch is just making a clicking noise when I press it and will not open. I've read that on more recent models there is a pull-tab. Is...
  20. Fuel flap mystery !

    Range Rover Sport / L320
    Hi, I wonder if anyone noticed that the owner handbook for the RR sport HSE 2010 clearly indicates that the fuel filler flap can be locked/unlocked with the remote-smart key .. ? ! The fact of this matter is that it strangely does not lock at all and there is no mention or memo regarding...
Top