RangeRovers.net Forum banner

egr

  1. DPF removal, EGR removal and or remap

    Range Rover Mark III / L322
    Hi friends worldwide, Yesterday a 2008 TDV8 came back in. It was originally sold to Italy and has been here for 7 years now. In spite of doing various cleaning cycles, which are pretty pointless with our bad diesel, his DPF error now comes back to bite him. He gets a message which translates...
  2. EGR Valve - should valve/piston slide easily when out of car

    Range Rover Mark III / L322
    Hi Not sure if this topic has been covered but i can't find the answer. I have removed my EGR valve from my L322 TDv6 04 to clean as it was really gunked up. Its come up nice and clean but my question is should the piston/valve move easily when not in the car. I have tried to move with my...
  3. vacuum line diagram (2005) td6 l322

    Range Rover Mark III / L322
    Hi, does anyone have a complete diagram of vacuum lines of RR l322 3.0 diesel CHEERS
  4. 3.0Tdv6 EGR turn off

    Range Rover Sport / L320
    Hi all, is it possible to turn the egr valves off with a scan tool like the Hawkeye or i930. Or does it have to be done with the computer reflash. Cheers
  5. EGR & Injector No4 sensor issues

    Range Rover Mark II / P38
    Hi I have a P38 2.5 DSE (BMW Engine) 1994, Manual. Here in Portugal sent the car to the local (Southern Portugal) garage (as i didnt have time) for new leak off pipes, fuel lines, glow plugs, filter etc. On return engine check light was on and i had a very fast (1500rpm) tickover when hot, i...
  6. 2.5 Diesel EGR valve leaking - replace or blank it off?

    Range Rover Mark II / P38
    Hi guys, 1998 P38 2.5 Diesel - BMW engine. In my constant pursuit of oil leaks I have found my EGR valve is blowing oil out of the "vent hole" on the underside. I think this means the diaphragm is shot so it needs replacing. I noticed blanking kits on ebay for £30 delivered which might be...
  7. EGR valve problem

    Range Rover Mark III / L322
    I have a L322 2011 3,6 TDV8 Vogue. A triangular red sign has appeared and service has informed it's EGR valve. Do I have to change it and if yes is it better to make replacement of both.? Thx in advance for all comments.
  8. Can i get this bit from EGR valve

    Range Rover Mark III / L322
    Hi Folks i am a newbie and i have a 2008 Range Rover Vogue with a 3.6L TDV8 I have been having problems with the LHS EGR valve not closing or opening properly. I have removed both but the LHS side cooler has a broken valve in the rear coolent pipe. Please see the photo. Is this important or...
  9. 1998 P38 2.5 BMW EGR vacuum hoses.

    Range Rover Mark II / P38
    Just putting my engine back together and have no idea where the hoses go to. It iS the EGR model. There is a pipe running under the inlet manifold which had no hose on it and there is a small valve on the passenger bulkhead that looks like it needs something going to it. Also there is a hose...
  10. EGR Valve failure, symptoms and fix.

    Range Rover Mark III / L322
    My wife was driving our 2007 RR TDV8 when the engine lost power however she made it back the last mile to home. When I subsequently started the engine the engine warning light came on and clouds of white smoke came from the exhaust and the engine ran rough. I purchased an OBDII diagnostic...
  11. egr valve leaking

    Range Rover Mark II / P38
    I have a 2002 p38 diesel and the egr valve seems to be leaking oil, why is that and is there a repair for it
  12. Rrs TDV8 EGR

    Range Rover Mark III / L322
    Any one know where to get a pair of EGRs at sensible price( lowest lol) Many thanks Paul
  13. Tdv8 egr

    Range Rover Sport / L320
    Anyone know of where best price is for a pair of EGRs Many thanks Paul
  14. RR diesel 2.5 chip/power box and removing/blanding EGR

    Range Rover Mark II / P38
    Has anyone tryed those cheap power boxes from ebay ? I find it a litle hard to belive that by pampering with only 2-4 wiers. To Get better power and lower fule comsumpsion. And will removing/blanking the EGR giver me any fault codes ? Like this box below...
  15. EGR problem

    Range Rover Sport / L320
    Hello! Cold morning here and some minor problems occured on my precious car. Its a sport -07 2.7l HSE. After the start the engine fault light came on. After I took off I felt reduced power on low rpm. Heard that it is caused by the EGR valves. Following codes occured: P0405 P045D C112F C1130...
  16. TDV8 RR EGR Valve

    Range Rover Mark III / L322
    Hello all I have a 2010 model RR Vogue SE which has just reported 'restricted performance' A quick code read from a mate suggests EGR valve B is the cause. Which side is EGR Valve B? Where on the engine is the EGR valve? Does anyone have fitting instructions? Many thanks Simon
  17. EGR blanking a 2010 3.6..

    Range Rover Mark III / L322
    Has anyone ever blanked off the EGR valves on a 2010 Vogue 3.6 engine? I did it on my other car an L200 pick up, but not sure if its just as easy with the V8 diesel? Are there kits or is not advisable? Thanks Mike
  18. 4.4 EGR Valve - Smoke Testing

    Range Rover Mark III / L322
    Newbie on the forum needing a bit of insight please: 2006 L322-HSE / 4.4 Jag / non-SC / 105K Miles I am smoke testing my emission system and discovered a bit of a leak near the top of the EGR valve. Leaking where the solenoid body mates with the coolant/heating jacket body. Not much of a...
  19. EGR valve removal / blocking

    Range Rover Mark II / P38
    This could well be a question that's been asked before. I did try the search function, however seeing as the search function refuses to accept three letter words and all I got was twenty pages of blocking valve queries :roll:. I thought it best to ask again. On with the subject. What are the...
  20. Post 99 MAF and EGR cars: Air temp sensor question

    Range Rover Mark II / P38
    On post 99 cars, the IAT was removed and the MAF was used to provide air measurements, mainly to control the EGR. So, when I plug my Nanocom Evolution in to the car and check the live data, I get a result of -38.88'c for the outside air temp. Clearly not right. But is this normal because the...
Top